Complaints Reported By The Department Of Transportation For
1992 GMC Vehicles
This data is brought to you by AboutPolitics.com
Select A Complaint From The List Below For More Details
|
GMC: G |
| Complaint Description | View Details |
 Fuel Efficiency Ratings for
1992 GMC: G Vehicles
Data provided by U.S. Department of Energy and the EPA |
| Model | Displacement | Cylinders | Transmission | Drive | City MPG | Highway MPG |
Recall Information for
1992 GMC: G Vehicles
Data provided by the National Highway Traffic Safety Administration (NHTSA) |
| Recalled Component | FUEL SYSTEM, GASOLINE |
| Description of Defect | CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE. |
| Consequences of Defect | THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR. |
| Corrective Action | HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1). |
| Notes | THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV. |
|
| Recalled Component | SERVICE BRAKES, HYDRAULIC:POWER ASSIST |
| Description of Defect | THE BRAKE PEDAL ASSEMBLY HAS A PUSHROD PIN THAT IS TOO SMALL AND IT IS INSTALLED IN THE WRONG POSITION, CAUSING AN INCREASED BRAKE PEDAL RATIO AND A DECREASED MASTER CYLINDER STROKE. |
| Consequences of Defect | THE REDUCED MASTER CYLINDER STROKE RESULTS IN FAILURE TOMEET THE PARTIAL SYSTEM FAILURE REQUIREMENTS OF FMVSS 105, "HYDRAULIC BRAKESYSTEMS". A FURTHER REDUCTION IN BRAKING ABILITY AT A TIME WHEN PARTIAL SYSTEMFAILURE HAS OCCURRED COULD RESULT IN A VEHICLE CRASH. |
| Corrective Action | REPLACE THE BRAKE ASSEMBLY. |
| Notes | SYSTEM: BRAKES: BRAKE PEDAL ASSEMBLY; FMVSS 105.VEHICLE DESCRIPTION: VANS EQUIPPED WITH VACUUM POWER BRAKES.NOTE: FMVSS 105 REQUIRES THAT HYDRAULIC BRAKE SYSTEMS HAVE AN EMERGENCY FEATUREWHICH STOPS THE VEHICLE UNDER SPECIFIED CONDITIONS. ALL HYDRAULIC BRAKE SYSTEMSARE DESIGNED WITH A SPLIT SYSTEM. EACH SPLIT WORKS INDEPENDENTLY FROM THE OTHER.THE PARTIAL SYSTEM FAILURE TEST OF THE FMVSS IS PERFORMED WITH ONE OF THE SPLITSYSTEMS INOPERATIVE. |
|
| Recalled Component | FUEL SYSTEM, GASOLINE |
| Description of Defect | CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE. |
| Consequences of Defect | THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR. |
| Corrective Action | HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1). |
| Notes | THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV. |
|
| Recalled Component | SERVICE BRAKES, HYDRAULIC:POWER ASSIST |
| Description of Defect | THE BRAKE PEDAL ASSEMBLY HAS A PUSHROD PIN THAT IS TOO SMALL AND IT IS INSTALLED IN THE WRONG POSITION, CAUSING AN INCREASED BRAKE PEDAL RATIO AND A DECREASED MASTER CYLINDER STROKE. |
| Consequences of Defect | THE REDUCED MASTER CYLINDER STROKE RESULTS IN FAILURE TOMEET THE PARTIAL SYSTEM FAILURE REQUIREMENTS OF FMVSS 105, "HYDRAULIC BRAKESYSTEMS". A FURTHER REDUCTION IN BRAKING ABILITY AT A TIME WHEN PARTIAL SYSTEMFAILURE HAS OCCURRED COULD RESULT IN A VEHICLE CRASH. |
| Corrective Action | REPLACE THE BRAKE ASSEMBLY. |
| Notes | SYSTEM: BRAKES: BRAKE PEDAL ASSEMBLY; FMVSS 105.VEHICLE DESCRIPTION: VANS EQUIPPED WITH VACUUM POWER BRAKES.NOTE: FMVSS 105 REQUIRES THAT HYDRAULIC BRAKE SYSTEMS HAVE AN EMERGENCY FEATUREWHICH STOPS THE VEHICLE UNDER SPECIFIED CONDITIONS. ALL HYDRAULIC BRAKE SYSTEMSARE DESIGNED WITH A SPLIT SYSTEM. EACH SPLIT WORKS INDEPENDENTLY FROM THE OTHER.THE PARTIAL SYSTEM FAILURE TEST OF THE FMVSS IS PERFORMED WITH ONE OF THE SPLITSYSTEMS INOPERATIVE. |
|
| Recalled Component | FUEL SYSTEM, GASOLINE |
| Description of Defect | CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE. |
| Consequences of Defect | THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR. |
| Corrective Action | HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1). |
| Notes | THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV. |
|
| Recalled Component | VISIBILITY:GLASS, SIDE/REAR |
| Description of Defect | VEHICLES WERE INCORRECTLY EQUIPPED WITH STANDARD REAR WINDOWS INSTEAD OF THE NECESSARY RIVETED INSTALLATION SEAL ASSEMBLIES. |
| Consequences of Defect | THE REAR DOOR WINDOWS DO NOT COMPLY WITH THE RETENTIONREQUIREMENTS OF FMVSS 217, WHICH PROVIDES PROTECTION AGAINST PASSENGERS BEINGEJECTED OUT OF THE REAR IN AN ACCIDENT. |
| Corrective Action | REPLACE THE EXISTING REAR WINDOW SEALS WITH THE RIVETED INSTALLATION SEAL ASSEMBLIES. |
| Notes | SYSTEM: VISUAL SYSTEMS; FMVSS 217.VEHICLE DESCRIPTION: CONVERSION VANS EQUIPPED WITH REAR WINDOW DEFOGGER. |
|
| Recalled Component | SUSPENSION:FRONT:CONTROL ARM:LOWER ARM |
| Description of Defect | THE LOWER CONTROL ARM CAN CRACK AT THE FLANGE ON THE END OF THE CONTROL ARM NEAR THE BALL JOINT PAD. |
| Consequences of Defect | THE BALL JOINT CAN SEPARATE FROM THE CONTROL ARM RESULTING IN LOSS OF STEERING CONTROL. |
| Corrective Action | DEALERS WILL INSTALL A REINFORCEMENT BRACE ON EACH OF THE FRONT LOWER CONTROL ARMS. |
| Notes | SYSTEM: SUSPENSION; INDEPENDENT FRONT SUSPENSION; LOWER CONTROL ARM.VEHICLE DESCRIPTION: PASSENGER VANS OVER 9200 LBS. GROSS VEHICLE WEIGHT.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASE CONTACT CHEVROLET SERVICE CENTER AT 1-800-222-1020 OR GMC SERVICE CENTER AT 1-313-456-4547. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393. |
|
| Recalled Component | SERVICE BRAKES, HYDRAULIC:POWER ASSIST |
| Description of Defect | THE BRAKE PEDAL ASSEMBLY HAS A PUSHROD PIN THAT IS TOO SMALL AND IT IS INSTALLED IN THE WRONG POSITION, CAUSING AN INCREASED BRAKE PEDAL RATIO AND A DECREASED MASTER CYLINDER STROKE. |
| Consequences of Defect | THE REDUCED MASTER CYLINDER STROKE RESULTS IN FAILURE TOMEET THE PARTIAL SYSTEM FAILURE REQUIREMENTS OF FMVSS 105, "HYDRAULIC BRAKESYSTEMS". A FURTHER REDUCTION IN BRAKING ABILITY AT A TIME WHEN PARTIAL SYSTEMFAILURE HAS OCCURRED COULD RESULT IN A VEHICLE CRASH. |
| Corrective Action | REPLACE THE BRAKE ASSEMBLY. |
| Notes | SYSTEM: BRAKES: BRAKE PEDAL ASSEMBLY; FMVSS 105.VEHICLE DESCRIPTION: VANS EQUIPPED WITH VACUUM POWER BRAKES.NOTE: FMVSS 105 REQUIRES THAT HYDRAULIC BRAKE SYSTEMS HAVE AN EMERGENCY FEATUREWHICH STOPS THE VEHICLE UNDER SPECIFIED CONDITIONS. ALL HYDRAULIC BRAKE SYSTEMSARE DESIGNED WITH A SPLIT SYSTEM. EACH SPLIT WORKS INDEPENDENTLY FROM THE OTHER.THE PARTIAL SYSTEM FAILURE TEST OF THE FMVSS IS PERFORMED WITH ONE OF THE SPLITSYSTEMS INOPERATIVE. |
|
| Recalled Component | SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION:LINES AND FITTINGS |
| Description of Defect | VEHICLE DESCRIPTION: CLASS 8 HEAVY DUTY TRUCKS. THE AIR SUSPENSION CONTROL VALVE SUPPLY LINE WAS NOT PLUMBED THROUGH AN AIR PRESSURE PROTECTION VALVE. IN THE EVENT OF A FAILURE, THERE WOULD BE LOSS OF AIR PRESSURE IN THE 'B' SYSTEM AIR RESERVOIR THAT SUPPLIES AIR PRESSURE FOR THE FRONT STEER AXLE BRAKES. |
| Consequences of Defect | THIS CONDITION WOULD RESULT IN INCREASED STOPPING DISTANCES. |
| Corrective Action | DEALERS WILL INSTALL THE NECESSARY AIR PRESSURE PROTECTION VALVE. |
| Notes | OWNER NOTIFICATION BEGAN DURING NOVEMBER 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236). |
|
| Recalled Component | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Description of Defect | A MISADJUSTED TRANSMISSION CABLE CAN ALLOW THE ENGINE TO BE STARTED WHILE THE TRANSMISSION IS IN A FORWARD OR REVERSE DRIVE GEAR. |
| Consequences of Defect | THE VEHICLE CAN BE STARTED AND THEN MOVE IN AN UNEXPECTEDDIRECTION, RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING. THE VEHICLE ALSOFAILS TO COMPLY WITH THE REQUIREMENTS OF FMVSS 102. |
| Corrective Action | RESET THE TRANSMISSION CABLE ROUTING TO A REVISED PATHWAY. |
| Notes | SYSTEM: AUTOMATIC TRANSMISSION; FMVSS 102.VEHICLE DESCRIPTION: VANS EQUIPPED WITH AUTOMATIC TRANSMISSIONS. |
|
| Recalled Component | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Description of Defect | A MISADJUSTED TRANSMISSION CABLE CAN ALLOW THE ENGINE TO BE STARTED WHILE THE TRANSMISSION IS IN A FORWARD OR REVERSE DRIVE GEAR. |
| Consequences of Defect | THE VEHICLE CAN BE STARTED AND THEN MOVE IN AN UNEXPECTEDDIRECTION, RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING. THE VEHICLE ALSOFAILS TO COMPLY WITH THE REQUIREMENTS OF FMVSS 102. |
| Corrective Action | RESET THE TRANSMISSION CABLE ROUTING TO A REVISED PATHWAY. |
| Notes | SYSTEM: AUTOMATIC TRANSMISSION; FMVSS 102.VEHICLE DESCRIPTION: VANS EQUIPPED WITH AUTOMATIC TRANSMISSIONS. |
|
| Recalled Component | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Description of Defect | A MISADJUSTED TRANSMISSION CABLE CAN ALLOW THE ENGINE TO BE STARTED WHILE THE TRANSMISSION IS IN A FORWARD OR REVERSE DRIVE GEAR. |
| Consequences of Defect | THE VEHICLE CAN BE STARTED AND THEN MOVE IN AN UNEXPECTEDDIRECTION, RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING. THE VEHICLE ALSOFAILS TO COMPLY WITH THE REQUIREMENTS OF FMVSS 102. |
| Corrective Action | RESET THE TRANSMISSION CABLE ROUTING TO A REVISED PATHWAY. |
| Notes | SYSTEM: AUTOMATIC TRANSMISSION; FMVSS 102.VEHICLE DESCRIPTION: VANS EQUIPPED WITH AUTOMATIC TRANSMISSIONS. |
|
| Recalled Component | EQUIPMENT |
| Description of Defect | CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES. |
| Consequences of Defect | THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE. |
| Corrective Action | HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075. |
| Notes | CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV. |
|
| Recalled Component | FUEL SYSTEM, GASOLINE |
| Description of Defect | CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE. |
| Consequences of Defect | THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR. |
| Corrective Action | HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1). |
| Notes | THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV. |
|
| Recalled Component | EQUIPMENT |
| Description of Defect | CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES. |
| Consequences of Defect | THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE. |
| Corrective Action | HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075. |
| Notes | CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV. |
|
| Recalled Component | FUEL SYSTEM, GASOLINE |
| Description of Defect | CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE. |
| Consequences of Defect | THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR. |
| Corrective Action | HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1). |
| Notes | THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV. |
|
| Recalled Component | EQUIPMENT |
| Description of Defect | CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES. |
| Consequences of Defect | THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE. |
| Corrective Action | HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075. |
| Notes | CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV. |
|
|
|
|
|
Political Site of the Day |
 |
WhatIfWeAllVoted.com
If the entire world could vote for our US president, who would they vote for?
http://whatifweallvoted.com
|
 | Submit a Site |
| Link to Us |
|
|
|
Forum 
