Complaints Reported By The Department Of Transportation For
9999 ALCOA Vehicles
This data is brought to you by AboutPolitics.com
Select A Complaint From The List Below For More Details
|
ALCOA: ALCOA |
| Complaint Description | View Details |
| EQUIPMENT:RECREATIONAL VEHICLE |
Read Details...
|
 Fuel Efficiency Ratings for
9999 ALCOA: ALCOA Vehicles
Data provided by U.S. Department of Energy and the EPA |
| Model | Displacement | Cylinders | Transmission | Drive | City MPG | Highway MPG |
Recall Information for
9999 ALCOA: ALCOA Vehicles
Data provided by the National Highway Traffic Safety Administration (NHTSA) |
| Recalled Component | WHEELS:RIM |
| Description of Defect | EQUIPMENT DESCRIPTION: FORGED ALUMINUM BUS WHEELS, SIZE 22.5" X 8.25", PART NO. 883613, AND SHIPPED TO OEMS. THESE WHEELS ARE BELOW DESIGN SPECIFICATIONS AND INTERNAL REQUIREMENTS WHICH CAN CAUSE THE UNSUPPORTED OPEN END OF THE WHEEL TO DEFORM, RESULTING IN SUDDEN LOSS OF AIR. |
| Consequences of Defect | LOSS OF AIR PRESSURE AND POSSIBLE TIRE/RIM SEPARATION FROM THE VEHICLE COULD RESULT IN LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH. |
| Corrective Action | ALCOA WILL REPLACE THESE WHEELS. |
| Notes | OWNER NOTIFICATION BEGAN APRIL 26, 1999.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THE OEM OR ALCOA AT 1-412-553-2391.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236). |
|
| Recalled Component | WHEELS:LUGS/NUTS/BOLTS |
| Description of Defect | SOME TWO-PIECE WHEEL CAP NUTS HAVE A FAULTY WASHER SECTION THAT CANNOT BE DETECTED BY THE NAKED EYE. THIS DEFECT MAY LEAD TO CRACKING OF THE WASHER SECTION WHICH CAN CAUSE NUT TO LOOSEN. EVENTUALLY, THE NUTS COULD FALL OFF AND THE WHEEL WOULD BECOME DETACHED FROM THE VEHICLE. |
| Consequences of Defect | |
| Corrective Action | OLD CAP NUTS WILL BE REPLACED WITH NEW NUTS (IDENTIFIED BY A DIMPLE). REPLACEMENT WILL BE DONE ONE CAP NUT AT A TIME, WITHOUT JACKING THE VEHICLE. THERE IS NO CHARGE FOR REPLACEMENT. |
| Notes | VEHICLE CATEGORY: MOTOR HOME.SYSTEM: SUSPENSION; WHEEL CAP-COVER.CONSEQUENCES OF DEFECT: LOSS OF A WHEEL COULD RESULT IN LOSS OF VEHICLE CONTROLAND A POSSIBLE ACCIDENT. |
|
| Recalled Component | WHEELS:CENTER SECTION |
| Description of Defect | THE WHEELS CONTAIN PILOT BORES WHICH ARE BELOW THE MINIMUM SPECIFIED DIAMETER. CONSEQUENCE OF DEFECT: IF THE ABOVE CONDITION EXISTS, IT COULD INTERFERE WITH THE PROPER MOUNTING AND POTENTIALLY CAUSE STUD BREAKAGE, LOSS OF WHEEL AND MAY RESULT IN LOSS OF VEHICLE CONTROL WHICH COULD LEAD TO AN ACCIDENT. |
| Consequences of Defect | |
| Corrective Action | INSPECT AND MAKE NECESSARY REPAIRS. |
| Notes | SYSTEM: WHEELS/ALUMINUM FORGED DISC TRUCK WHEELS. VEHICLE CATEGORY: TRUCKS. |
|
| Recalled Component | WHEELS |
| Description of Defect | THE INVOLVED WHEELS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS", DUE TO IMPROPER RIM SIZE MARKING. |
| Consequences of Defect | |
| Corrective Action | THE IMPRORERLY MARKED WHEELS WILL BE CORRECTED BY REMOVING THE IMPRESSION STAMPED CHARACTER ".5" FOLLOWING THE NUMERICAL CHARACTERS 22. |
| Notes | VEHICLE CATEGORY: TRUCKS.SYSTEM: WHEELS; ALCOA ALUMINUM, PART NOS. 472000 AND 472001.CONSEQUENCES OF DEFECT: INCORRECT RIM MARKING COULD RESULT IN THE SELECTION OFINCORRECT REPLACEMENT TIRES, POSSIBLY LEADING TO LOSS OF VEHICLE CONTROL AND ANACCIDENT. |
|
| Recalled Component | WHEELS |
| Description of Defect | |
| Consequences of Defect | |
| Corrective Action | |
| Notes | POSSIBILITY THAT WHEELS WERE MACHINED IN A CONVEX OUT-OF-FLAT CONDITION ON THEINSIDE WHEEL MOUNTING SURFACE.IF THIS CONDITION EXIST IT MAY INCREASE THEASSEMBLY STRESS ON THE HUB TO AN UNDESIRABLE LIMIT.(CORRECT BY INSPECTING ANDREPLACING WITH PROPER WHEEL). |
|
|
|
Forum 
